Common Problems and Solutions about Flexi Light

November 25,2021

Wholesale China Oem Flexi Strip Light

With the improvement of people's living standards, flexi lights have been instalLED in every corner of the home, such as cloakrooms, drawers, and cabinets. Among them, LED flexi lights are widely used. Do you know why?


Shelf Lighting,Flexi Light Manufacturer,Led Shelf Light Factory


Compared with incandescent lamps and fluorescent lamps, the price of LED linear lamps is indeed higher. However, due to the extremely low energy consumption of LED, a large amount of electricity bills can be saved in the long-term, and the investment in lamp replacement can be saved, so the comprehensive use cost is more cost-effective.


Advantages of LED flexi lights


The shell of the LED linear lamp is made of aluminum alloy, which has the advantages of clear lines, simple structure, beautiful appearance, sturdiness, corrosion resistance, and convenient installation. The surface of the LED linear lamp is electrostatically sprayed, which has good high temperature resistance and weather resistance. The reflector of LED linear lamp adopts imported anodized aluminum plate to ensure high output of light energy. 3MM thick high-strength tempered glass makes it high light transmittance and impact resistance.


  • The built-in LEDlinear lamp has a guaranteed protection level up to IP65.


  • Color range: red, yellow, blue, green, white and color.


  • The beam angle of the LEDline light: 15°-60°.


  • Lighting distance of LEDline light: 20 meters.


  • LEDlinear light control system: DMX512 controller or simple wall washer controller.


  • Shell material of LEDlinear lamp: aluminum alloy.


  • LEDline light connection method: standard signal power cord connector 3-pin signal connector.


Common problems and their solutions


In the process of using LED line lights, some failures may occur. We have summarized some experience and hope to give you some reference.


LED line light does not light, please check whether the circuit is connected, whether the connection is poor, whether the positive and negative poles of the light bar are connected reversely. The brightness of the light bar is obviously low, please check whether the rated power of the power supply is less than the power of the light bar, or whether too much power is consumed because the connecting wire is too thin. If the front of the light bar is obviously brighter than the back, please check whether the series length exceeds 3 meters.


LED line lights need to be anti-static: because LED is an electrostatic sensitive component, if you do not take anti-static measures when repairing LED line lights, the LED will burn out and cause waste. It should be noted here that the soldering iron must use an anti-static soldering iron, and the maintenance personnel must also take anti-static measures (such as wearing a static ring and anti-static gloves, etc.)


LED linear lights cannot sustain high temperature: The two important components of linear light manufacturers' LED linear lights are LED and FPC. LED linear lights are products that cannot continue to withstand high temperatures. If the FPC continues to high temperature or exceeds its withstand temperature, the cover film of the FPC will bubble, which will directly cause the LED line lamp to be scrapped. At the same time, the LED cannot withstand the high temperature continuously, and the LED linear lamp chip will be burned out by the high temperature for a long time under the high temperature. Therefore, the soldering iron used when repairing the LED light strip must be a temperature-control LED soldering iron, and the temperature is limited to a range, and it is forbidden to change and set at will. In addition, even so, it is necessary to pay attention to the soldering iron not to stay on the pins of the LED line lamp for more than 10 seconds during maintenance. If it exceeds this time, it is likely to burn the LED line lamp chip. 


Hoping that the above content can give you some references. We are leading and professional LED lights manufacturer, providing china oem flexi light, if you have any requirements, please feel free to contact us by

Wholesale China Oem Flexi Strip Light